Hyundai Santa Cruz Owners & Service Manuals

Hyundai Santa Cruz: Air Conditioning System / Compressor oil

- Oil Specification

1.The R-134a or R-1234yf system requires synthetic (PAG) compressor oil whereas the R-12 system requires mineral compressor oil. The two oils must never be mixed.

2.Compressor (PAG) oil varies according to compressor model. Be sure to use oil specified for the model of compressor.

Handling of Oil

1.The oil should be free from moisture, dust, metal powder, etc.

2.Do not mix with other oil.

3.The water content in the oil increases when exposed to air. After use, seal oil from air immediately. (R-134a or R-1234yf Compressor Oil absorbs moisture very easily.)

4.The compressor oil must be stored in steel containers, not in plastic containers.

Compressor Oil Check The oil used to lubricate the compressor circulates with the refrigerant.Whenever replacing any component of the system or a large amount of gas leakage occurs, add oil to maintain the original amount of oil.

Oil total volume in system :FD46XG (IDEMITSU) 100 ± 10g (3.53 ± 0.3 oz.)

Oil Return Operation There is close affinity between the oil and refrigerant.During normal operation, part of the oil recirculates with the refrigerant in the system. When checking the amount of oil in the system, or replacing any component of the system, the compressor must run in advance for oil return operation. The procedure is as follows :

1.Open all the doors and engine hood.

2.Start the engine and air conditioning switch to "ON" and set the blower motor control knob at its highest position.

3.Run the compressor for more than 20 minutes between 800 and 1,000 rpm in order to operate the system.

4.Stop the engine.

    Repair procedures
    - Refrigerant System Service Basics Refrigerant Identification • Do not mix HFO-1234yf (R-1234yf) in the vehicle with other refrigerant, such as R-12, R-134a and etc. • Use only service eq ...

    Refrigerant Line
    - Components 1. Suction & Liquid Pipe Assembly - Replacement 1.If a compressor is available, the air conditioner is operated for a few minutes in the engine idle state and then the ...

    Other information:

    Hyundai Santa Cruz 2021-2025 Owners Manual: Second row center seatbelt (3-point rear center seat belt)
    1. Insert the tongue plate (1) into the buckle (2) until an audible “click" is heard, indicating the latch is locked. Make sure the belt is not twisted. When using the rear center seat belt, the buckle with the “CENTER” mark must be used. Information If you are not able to pull out the s ...

    Hyundai Santa Cruz (NX4A OB) 2021-2025 Service Manual: Accelerator Pedal
    - Removal 1.Turn the ignition switch OFF and disconnect the battery (-) terminal. 2.Disconnect the accelerator position sensor connector (A). 3.Remove the mounting cap (B). 4.Remove the accelerator pedal module from the vehicle after loosening the mounting bolt (A).Tightening Torque :8.8 ...

    © 2023-2025 Copyright www.hysacr.com